fuel cap Ram 1500 2014 Get to Know Guide 

Diesel Exhaust Fluid (DEF) Warning Messages
Your vehicle will begin displaying warning messages when the DEF level reaches a
driving range of approximately 350 miles (563 km). If the following warning message
sequence is ignored, your vehicle may be limited to a maximum speed of 5 MPH
(8 km/H) unless DEF is added.
•DEF Low Refill Soon — This message will display when the low level is reached,
during vehicle start up, and with increased frequency during vehicle operation.
It will be accompanied by a single chime. Approximately 5 gallons (19 Liters) of
DEF is required to refill the tank when this message is initially displayed on pickup
applications, and approximately 7 gallons (28 Liters) are required on chassis-cab
applications.
• Speed Limited to 5 MPH in XXX mi Refill DEF — This message will continuously
display if the “DEF Low Refill Soon” message is ignored, and the frequency of
occurance of the chime will increase unless up to 2 gallons (7.5 Liters) of DEF is
added to the tank.
• 5 MPH Max Speed on Restart, Long Idle or Refuel Refill DEF — This message will
continuously display when the counter reaches zero, and will be accompanied by
a periodic chime.
The vehicle will only be capable of a maximum speed of 5 MPH upon the first of the
following conditions to occur: • If the vehicle is shutoff and restarted.
• If the vehicle is idled for an extended period of time, approximately one hour orgreater.
• If the system detects that the level of fuel in the tank has increased.
Add a minimum of 2 gallons (9.5 Liters) of DEF to the tank in order to avoid vehicle
operation at a maximum speed of 5 MPH (8 km/H).
• 5 MPH Max Speed Refill DEF — The vehicle will only be capable of a maximum
speed of 5 MPH (8 km/H) when this message is displayed. Add up to 2.5 gallons
(9.5 Liters) of DEF to the tank to restore normal vehicle operation.
NOTE:
A minimum of 2 gallons (9.5 Liters) may be required to restore normal vehicle
operation. Although the vehicle will start normally and can be placed in gear after this
message has been initially displayed, extreme caution should be utilized since the
vehicle will only be capable of maneuvering at a maximum speed of 5 MPH (8 km/H).
6.7L CUMMINS® DIESEL
167

Diesel Exhaust Fluid (DEF) Fault Warning Messages
There are four different messages which are displayed if the vehicle detects that the
DEF system has been filled with a fluid other than DEF, has experienced component
failures, or when tampering has been detected. The vehicle may be limited to a
maximum speed of 5 MPH (8 km/H) if the DEF system is not serviced within less than
250 miles (402 km) of the fault being detected.
When the DEF system needs to be serviced the following warnings will display:
•Service DEF System – See Dealer — This message will display when the fault is
initially detected, each time the vehicle is started, and periodically during driving.
The message will be accompanied by a single chime. We recommend you drive to
your nearest authorized dealer and have your vehicle serviced as soon as possible.
• 5 MPH Max Speed in 150 mi Service DEF System See Dealer — This message will
display if the DEF system has not been serviced after the “Service DEF System –
See Dealer” message is displayed. This message will continuously display until the
mileage counter reaches zero, and will be accompanied by a periodic chime. The
message will continue to countdown until it reaches zero unless the vehicle is
serviced. We recommend you drive to your nearest authorized dealer and have your
vehicle serviced immediately.
NOTE:
Under some circumstances this mileage counter may start with a value of less than
150 miles (241 km). For example, if recurring faults are detected in a time interval
of less than 40 hours, the counter may restart at the value where it stopped when a
previous fault was temporarily remedied, or at a minimum of 50 miles (80 km).
• 5 MPH Max Speed on Restart, Long Idle or Refuel Service DEF See Dealer — This
message will continuously display when the mileage counter reaches zero, and will
be accompanied by a periodic chime.
The vehicle will only be capable of a maximum speed of 5 MPH upon the first of the
following conditions to occur: • If the vehicle is shutoff and restarted.
• If the vehicle is idled for an extended period of time, approximately one hour orgreater.
• If the system detects that the level of fuel in the tank has increased.
• 5 MPH Max Speed Service DEF System See Dealer — This message will continuously
display, and will be accompanied by a periodic chime. Although the vehicle can be
started and placed in gear, the vehicle will only operate at a maximum speed of
5 MPH. Your vehicle will require towing, see your authorized dealer for service.
NOTE:
When this message is displayed, the engine can still be started. However, the vehicle
will only operate at a maximum speed of 5 MPH.
6.7L CUMMINS® DIESEL
168

JUMP-STARTING
• If your vehicle has a discharged bat-tery it can be jump-started using a
set of jumper cables and a battery in
another vehicle or by using a portable
battery booster pack.
• Jump-starting can be dangerous if done improperly so please follow the
procedures in this section carefully.
NOTE:
When using a portable battery booster
pack follow the manufacturer’s operating
instructions and precautions.
Preparations For Jump-Start
• The battery in your vehicle is located in the front of the engine compartment, behind the left headlight assembly.
NOTE:
The positive battery post is covered with a protective cap. Lift up on the cap to gain
access to the positive battery post.
• Set the parking brake, shift the automatic transmission into PARK and turn the ignition to OFF.
• Turn off the heater, radio, and all unnecessary electrical accessories.
• If using another vehicle to jump-start the battery, park the vehicle within the jumper cables reach, set the parking brake and make sure the ignition is OFF.
Jump-Starting Procedure
1. Connect the positive (+)end of the jumper cable to the positive (+)post of the
vehicle with the discharged battery.
2. Connect the opposite end of the positive (+)jumper cable to the positive (+)post
of the booster battery.
3. Connect the negative (-)end of the jumper cable to the negative (-)post of the
booster battery.
4. Connect the opposite end of the negative (-)jumper cable to a good engine ground
(exposed metal part of the discharged vehicle’s engine) away from the battery and
the fuel injection system.
5. Start the engine in the vehicle that has the booster battery, let the engine idle a few minutes, and then start the engine in the vehicle with the discharged battery.
WHAT TO DO IN EMERGENCIES
190

ComponentFluid, Lubricant, or
Genuine Part Capacities
Power Steering Reservoir –
2500/3500 Models We recommend you use
MOPAR
®Power Steering
Fluid +4 or MOPAR®
ATF+4®Automatic
Transmission Fluid. —
Fuel Selection 3.6L 87 Octane1500 Regular Cab
Shortbed/Crew Quad Cab - 26 Gallons (98 Liters) (Approximate)
1500 Regular Cab
Longbed/Crew Quad Cab (Optional) - 32 Gallons
(121 Liters) (Approximate) 2500/3500 Shortbed -
34 Gallons (129 Liters) (Approximate)
2500/3500 Longbed -
35 Gallons (132 Liters) (Approximate)
Fuel Selection 5.7L 87 Octane Acceptable.
89 Octane Recommended. 1500 Regular Cab
Shortbed/Crew Quad Cab - 26 Gallons (98 Liters) (Approximate)
1500 Regular Cab
Longbed/Crew Quad Cab (Optional) - 32 Gallons
(121 Liters) (Approximate) 2500/3500 Shortbed -
31 Gallons (117 Liters) (Approximate)
2500/3500 Longbed -
32 Gallons (121 Liters) (Approximate)
Fuel Selection 6.4L 87 Octane2500/3500 Shortbed -
34 Gallons (129 Liters)
(Approximate) 2500/3500 Longbed - 35 Gallons
(132 Liters) (Approximate)
MAINTAINING YOUR VEHICLE
208

ComponentFluid, Lubricant, or
Genuine Part Capacities
Fuel Selection 3.0L Turbo
Diesel – 1500 Models Only Use good quality diesel
fuel from a reputable
supplier in your vehicle.
Federal law requires that
you must fuel this vehicle with Ultra Low SulfurHighway Diesel fuel
(15 ppm Sulfur maximum) and prohibits the use of
Low Sulfur Highway Diesel fuel (500 ppm Sulfur
maximum) to avoid damage to the emissions controlsystem. For most year-
round service, No. 2 diesel
fuel meeting ASTM specifi- cation D-975 Grade S15will provide good perfor-
mance. We recommend you useablendofupto5%
biodiesel, meeting ASTM specification D-975 with your diesel engine.
If the vehicle is exposed to extreme cold (below 20°For -7°C), or is required to operate at colder-than-normal conditions for
prolonged periods, use
climatized No. 2 diesel fuel or dilute the
No. 2 diesel fuel with 50% No. 1 diesel fuel. This will provide better protectionfrom fuel gelling or wax-
plugging of the fuel filter. This vehicle is compatible
with biodiesel blends greater than 5% but no greater than 20% biodiesel meeting
ASTM specification D-7467 provided the shortened
maintenance intervals are followed as directed. 26 Gallons (98.5 Liters)
(Approximate)
MAINTAINING YOUR VEHICLE
210

ComponentFluid, Lubricant, or
Genuine Part Capacities
Fuel Selection 6.7L Turbo
Diesel Use good quality diesel
fuel from a reputable
supplier in your vehicle.
Federal law requires that
you must fuel this vehicle with Ultra Low SulfurHighway Diesel fuel
(15 ppm Sulfur maximum) and prohibits the use of
Low Sulfur Highway Diesel fuel (500 ppm Sulfur
maximum) to avoid damage to the emissions controlsystem. For most year-
round service, No. 2 diesel
fuel meeting ASTM specifi- cation D-975 Grade S15will provide good perfor-mance. If the vehicle is
exposed to extreme cold
(below 20°F or -7°C), or is required to operate atcolder-than-normal
conditions for prolonged periods, use climatized
No. 2 diesel fuel or dilute the No. 2 diesel fuel with 50% No. 1 diesel fuel.
This will provide better pro- tection from fuel gelling or wax-plugging of the fuel
filters. This vehicle is fully
compatible with biodiesel
blends up to 5% biodiesel
meeting ASTM specification D-975. Pickup models,
and Chassis Cab models configured with optional
B20 capability, are addi- tionally compatible with20% biodiesel meeting ASTM specification
D-7467 if the Bio-Diesel
Fuel Requirements listed in the Owner’s Manual
Diesel Supplement are fully complied with. 2500/3500 Standard Cab
(Longbed) Models -
28 Gallons (106 Liters) 2500/3500 Crew/Mega
Cab (Shortbed) Models - 31 Gallons (117 Liters) 2500/3500 Crew Cab (Longbed) Models -
32 Gallons (121 Liters) Standard Rear Tank -
52 Gallons (197 Liters)
Optional Midship Tank - 22 Gallons (83 Liters)
MAINTAINING YOUR VEHICLE
211

ComponentFluid, Lubricant, or
Genuine Part Capacities
Engine Oil Filter
3.0L, 6.7L Diesel Engine We recommend you
use MOPAR
®Engine
Oil Filters. —
Engine Fuel Filter
3.0L Turbo Diesel –
1500 Models Only We recommend you use
MOPAR
®Fuel Filter.
Must meet 3 micron rating. Using a fuel filter that does
not meet the manufacturers
filtration and water separat- ing requirements can
severely impact fuel system life and reliability. —
Engine Fuel Filter
6.7L Turbo Diesel We recommend you use
MOPAR
®Fuel Filter.
Must meet 3 micron rating. Using a fuel filter that does
not meet the manufacturers
filtration and water separat- ing requirements can
severely impact fuel system life and reliability. —
Crankcase Ventilation Filter
6.7L Turbo Diesel We recommend you use
MOPAR
®CCV Filter. —
Automatic Transmission –
Eight-Speed Automatic
3.0 Turbo Diesel –
1500 Models Only We recommend you use
MOPAR
®ZF 8&9 Speed
ATF™ Automatic
Transmission Fluid. —
Automatic Transmission –
Six-Speed Automatic –
68RFE We recommend you use
MOPAR
®ATF+4®Auto-
matic Transmission Fluid. —
Automatic Transmission –
Six-Speed AISIN HD
Automatic MOPAR
®ASRC Automatic
Transmission Fluid or equivalent. —
Clutch Linkage We recommend you use
MOPAR
®Multi-Purpose
Grease, NLGI Grade 2 E.P. —
Manual Transmission
G-56 – 6.7L Diesel Engine We recommend you use
MOPAR
®ATF+4®Auto-
matic Transmission Fluid. —
Transfer Case We recommend you use
MOPAR
®BW44–44
Transfer Case Fluid. —
MAINTAINING YOUR VEHICLE
212

CAUTION!
• Mixing of engine coolant (antifreeze) other than specified Organic AdditiveTechnology (OAT) engine coolant (antifreeze), may result in engine damage and
may decrease corrosion protection. Organic Additive Technology (OAT) engine
coolant is different and should not be mixed with Hybrid Organic Additive
Technology (HOAT) engine coolant (antifreeze) or any “globally compatible”
coolant (antifreeze). If a non-OAT engine coolant (antifreeze) is introduced into
the cooling system in an emergency, the cooling system will need to be drained,
flushed, and refilled with fresh OAT coolant (conforming to MS-12106), by an
authorized dealer as soon as possible.
• Do not use water alone or alcohol-based engine coolant (antifreeze) products. Do not use additional rust inhibitors or antirust products, as they may not be
compatible with the radiator engine coolant and may plug the radiator.
• This vehicle has not been designed for use with propylene glycol-based engine coolant (antifreeze). Use of propylene glycol-based engine coolant (antifreeze)
is not recommended.
E-85 Flexible Fuel — 3.6L Engine Only
CAUTION!
Only vehicles with the E-85 fuel filler door label or a yellow gas cap can operate on
E-85.
Refer to your Owner's Manual on the DVD for further details.
MAINTENANCE SCHEDULE — GASOLINE ENGINE
Your vehicle is equipped with an automatic oil change indicator system. The oil
change indicator system will remind you that it is time to take your vehicle in for
scheduled maintenance.
Based on engine operation conditions, the oil change indicator message will
illuminate. This means that service is required for your vehicle. Operating conditions
such as frequent short-trips, trailer tow, extremely hot or cold ambient temperatures,
and E85 fuel usage will influence when the “Oil Change Required” message is
displayed. Severe Operating Conditions can cause the change oil message to
illuminate as early as 3,500 miles (5,600 km) since last reset. Have your vehicle
serviced as soon as possible, within the next 500 miles (805 km).
MAINTAINING YOUR VEHICLE
214

AdjustablePedals ...........31
Air BagAdvanceFrontAirBag ......16
AirBags ...............16
AirBagWarningLight....16,173
FrontAirBag ............16
Rollover ...............16
SideAirBags ............16
SideImpacts ............16
Air Conditioning .....43,44,45,46
Air Suspension ...........40,42
Alarm Arm The System ..........14
Disarm The System ........14
Vehicle Security Alarm ......14
Alarm (Security Alarm) .........14
Anti-Lock Brake System (ABS) . . .173
Assistance Towing ..........169
Automatic Headlights .........34
Automatic High Beams ........34
Automatic Temperature Control (ATC) ............45
Automatic Transmission FluidType ............205
AxleFluid...............205
Back-Up Camera ............47
Battery Charging System Light .....172
Brake Fluid ..............205
Brake System WarningLight ..........171
Break-In Recommendations, New Vehicle .............32
BulbReplacement ..........235
Calibration,Compass.........116
CargoLight...............34
ChangeOilIndicator.........174
Charging System Light ........172
Check Engine Light
(Malfunction Indicator Light)...172 Child Restraints
CarSeat ...............17
Child Restraints ..........17
Child Seat Installation ....18,19
Installing Child Restraints
Using The Vehicle Seat Belt . . .19
Lower Anchors And Tethers
For Children ..........17,18
ChildSeat................18
Climate Control ........43,44,45
Cluster Warning/Indicator Lights AirBagWarningLight ......173
Brake Warning Light .......171
Compass Calibration .........116
Cooling System Coolant Capacity .........205
Cruise Control (Speed Control) ....35
CruiseLight...............35
Customer Assistance .........236
Customer Programmable Features ..............117
Defects, Reporting ..........237
Defroster, Rear Window ......43,44
Defroster, Windshield .......43,44
Diesel Engine Maintenance . .147, 158
Diesel Exhaust Fluid ......151, 164
Diesel Fuel Water Separator . .147, 158
DimmerControl.............34
Disabled Vehicle Towing .......169
Disarming, Security System ......14
Electronic Range Select (ERS). .38, 39
Electronics Your Vehicle's Sound System . . .50
Electronic Speed Control (Cruise Control) ...........35
Electronic Stability Control (ESC). .169
Electronic Throttle Control WarningLight ...........173
Electronic Vehicle Information Center (EVIC) ...........116
INDEX
241

Emergency, In Case ofFreeing Vehicle When Stuck . .196
Overheating ............175
Towing ........... 169, 196
Engine Block Heater ...........155
Break-In
Recommendations . .32, 145, 155
Compartment ...........199
Malfunction Indicator
(CheckEngine) ..........172
OilSelection ...........205
Overheating ............175
Starting ...............13
Stopping ..............13
Event Data Recorder .........197
Exhaust Brake .............157
Exhaust Regeneration ........148
Exterior Lights .............235
Filters EngineFuel ........ 147, 158
FlatTireStowage...........188
Fluid Capacities ............205
Fluids .................205
FogLights................34
Freeing A Stuck Vehicle .......196
Front And Rear ParkSense System...46
Front Heated Seats ...........27
Front ParkSense System ........46
Fuel Specifications ..........205
Fuse ..................230
Fuses..................230
Garage Door Opener (HomeLink
®)............120
Headlight ................34
Headlights Automatic .............34
Dimmer Switch ..........34
HighBeam .............33
Switch ...............34 Head Restraints
............24
Heated Seats ..............27
Heated Steering Wheel ........30
Heater, Engine Block .........155
High Beam/Low Beam Select (Dimmer) Switch ..........33
HomeLink
®
(Garage Door Opener) .......120
Hood Release .............198
HubCaps ...............186
Idle Up Feature ............158
Integrated Trailer Brake Controls . .138
Interior and Instrument Lights . . .7, 51
Intermittent Wipers (Delay Wipers) ............33
Introduction ...............3
Inverter Outlet (115V) ........123
Inverter, Power ............123
Jack Location .............176
Jump Starting .............190
KeyFob.................10 Arm The Alarm ...........14
Disarm The Alarm .........14
Keyless Enter-N-Go ...........12
Lock/Unlock ............12
Starting/Stopping .........13
LaneChangeandTurnSignals....33
Lane Change Assist ..........33
LATCH (Lower Anchors and TetherforCHildren)....17,18,19
Lights
Engine Temperature Warning. .170
TurnSignal .............33
Maintenance Record. . .218, 224, 229
Maintenance Schedule.... 214, 219, 225, 227
Malfunction Indicator Light(CheckEngine).......172
MemorySeat ..............26
INDEX
242